一、启动前的日常保养

1、 Daily maintenance before startup

清洁检查

Cleaning inspection

彻底清洁榴莲视频在线观看污表面，确保无油污、灰尘堆积。

Thoroughly clean the surface of the generator set to ensure no oil stains or dust accumulation.

冷却系统检查

Cooling system inspection

检查水箱防冻液液面，应保持在水箱盖焊点下方5cm处，严禁超过上限。

Check the coolant level in the water tank, which should be kept 5cm below the welding point on the water tank cover, and it is strictly prohibited to exceed the upper limit.

检查水箱散热片及冷凝器内部，确保无杂物堵塞。

Check the radiator fins of the water tank and the interior of the condenser to ensure that there are no debris blockages.

空气滤清器检查

Air filter inspection

若阻塞指示器显示在蓝色区域，需停机并立即更换滤清器，禁止重复使用旧滤芯。

If the blockage indicator displays in the blue area, stop the machine and immediately replace the filter. Do not reuse the old filter element.

润滑油检查

Lubricating oil inspection

检查发动机机油油位，确保液面在机油尺最小与最大刻度之间。

Check the engine oil level to ensure that it is between the minimum and maximum marks on the dipstick.

电气系统检查

Electrical system inspection

检查控制系统机电连接线，确保无松动或接触不良。

Check the electromechanical connection wires of the control system to ensure that there is no looseness or poor contact.

二、运行结束后的日常保养

2、 Daily maintenance after operation

紧固检查

Tightening inspection

重点检查并紧固旋转部件螺母（如高压油泵、水泵、齿轮、风扇等），同时加固地脚螺栓。

Focus on inspecting and tightening the nuts of rotating components (such as high-pressure oil pumps, water pumps, gears, fans, etc.), while reinforcing the foundation bolts.

泄漏检查

Leakage inspection

检查是否存在漏油、漏水、漏气现象，必要时进行修复。

Check for oil, water, and gas leaks, and repair if necessary.

故障排查

Troubleshooting

记录运行过程中出现的异常现象或故障，及时分析处理。

Record any abnormal phenomena or faults that occur during operation, and analyze and handle them in a timely manner.

滤清器维护

Filter maintenance

清洁空气滤清器滤网，去除积尘。

Clean the air filter mesh and remove dust accumulation.

油液补充

Oil replenishment

检查机油液面及高压油泵油位，必要时添加符合技术标准的高品质机油。

Check the oil level and high-pressure oil pump level, and add high-quality engine oil that meets technical standards if necessary.

检查水箱冷却液液位，必要时补充软化水或防冻液。

Check the coolant level in the water tank and add softened water or antifreeze if necessary.

电气系统复查

Electrical system review

再次检查控制系统接线，确保无松动或老化。

Recheck the control system wiring to ensure there is no looseness or aging.

清洁整理

Cleaning and tidying up

全面清洁榴莲视频在线观看污表面，保持设备整洁。

Thoroughly clean the surface of the generator set and keep the equipment clean.

本文由沼气发电机友情奉献.更多有关的知识请点击:http://www.wqeshop.com榴莲视频IOS污将会对您提出的疑问进行详细的解答，欢迎您登录网站留言.

This article is a friendly contribution from a biogas generator For more information, please click: http://www.wqeshop.com We will provide detailed answers to your questions. You are welcome to log in to our website and leave a message